You’ve been granted free access to this subscribers only article.
Expert explains high cost of AC repair
On The Road AgainDecember 14, 2011 | 4,151 views | Post a comment
It’s no secret that auto air conditioning systems are expensive to repair when they quit working, but why is that? Air conditioning parts are like anything else, the price is generally based on supply and demand.
A compressor for an older model ’70s-era GM car could be as cheap as $100, and the sky is the limit on the upside. The worst I’ve seen so far was $1,450 for an older Toyota Camry compressor, which was a dealer-only part at the time. And of course, there are a lot more parts to an air conditioner than just the compressor under the hood. There are also the expensive electronics on the inside controlling everything.
In addition to high parts costs, all a/c systems aren’t built alike. Some aren’t too hard to work on, parts are exchanged easily, and there is plenty of room for access. Others can eat up labor hours.
For example, the evaporator is either installed under the dash or against the firewall under the hood, depending on the manufacturer. These little radiators are actually the part that gets very cold so the fan can blow the cold air into the vents, and they are almost always tough to get to should they need replacing. Sometimes, the wheel well has to be removed to gain access and then it is like performing surgery. Other times, the lower dash has to be disassembled which is tedious and awkward to get to if you’re bigger than 3 feet, 5 inches, and 80 pounds.
Honda CRVs are notorious for having bad compressors, and those owners have paid as much as $3,000 for repairs, according to the net. On this model, the compressor can be unbolted but not removed until the engine cradle is lowered a bit. In addition, the evaporator and expansion valve is several labor hours behind the dash in a maze of items that need removal to gain access. The first time into this dash you can lose an hour trying to figure out how to remove a few screws that seem impossible to access. Even the second time, it can take some time to do both the under-hood repair and the under-dash, because they are both labor-intense.
On the electronics side of the a/c systems, I know of some Volkswagen models that have a $600 electronic “module” that goes bad, and those aren’t the worst parts price offenders, by far. In addition to expensive parts and grueling labor hours to access and swap parts, add in the reclaiming, leak detection, pressure gauges, and other special tools and equipment needed to service these systems within the EPA’s guidelines, and you can understand why it costs so much to fix one of these systems.
Expensive and sometimes complicated, but when it’s more than 100 outside, it’s a worthwhile investment to keep it working -- at least in my view.
Send your vehicle maintenance questions to Jeff Deines. E-mail to email@example.com.
Your Opinions and Comments
Be the first to comment on this story!
You must be logged in to post a comment.
Agriculture Today Archives
Bull Classic Dec. 5 (November 25, 2015)
Davidson: Reduce antibiotic use, dispel beef myths (November 25, 2015)
EPA proposes changes to pesticide applicator rules (November 25, 2015)
Farm Bureau responds to beef cancer claims (November 25, 2015)
Hay & Forage Report (November 25, 2015)
Livestock disaster funding available (November 25, 2015)
Livestock Market Reports (November 25, 2015)
Llama competitors shine in state, national shows (November 25, 2015)
Plan to attend grazing lands conference (November 25, 2015)
Plant cool weather veggies (November 25, 2015)
Rancher’s Choice bull sale Dec. 5 (November 25, 2015)
Skills team places sixth (November 25, 2015)
TPWD announces annual trout stocking (November 25, 2015)
All Breed Bull Sale Nov. 21 in Nixon (November 18, 2015)
Clean Water Rule continues to make waves in Congress (November 18, 2015)
Conservation Service: Tips for planting winter pastures (November 18, 2015)
County committee elections begin (November 18, 2015)
Hay & Forage Report (November 18, 2015)
Here’s the beef: Patterson wins FFA national title (November 18, 2015)
Livestock Market Reports (November 18, 2015)
Moczygemba: Angus group CEO (November 18, 2015)
Onion recommendations (November 18, 2015)
A river runs through it: River changes spark border dispute (November 11, 2015)
Cold-sensitive oriental hibiscus (November 11, 2015)
Gov. Abbott: EPA’s Clean Power Plan is ‘power grab’ (November 11, 2015)
Hay & Forage Report (November 11, 2015)
Knowles winner of mule deer hunt package (November 11, 2015)
Letter: A war on Texas: Bureau of Land Management vs. Texas ranchers (November 11, 2015)
Livestock Market Reports (November 11, 2015)
Palo Alto College hosts FFA leadership conference (November 11, 2015)
Rodeo athletes place in Hallettsville contest (November 11, 2015)
‘Old Iron’ club show canceled! (November 11, 2015)
Antique Farm Equipment Demonstration and Field Day, Nov. 14 (November 4, 2015)
Cattlemen’s seminar Nov. 14 in Kosciusko (November 4, 2015)
Hay & Forage Report (November 4, 2015)
Impacts of rural land loss (November 4, 2015)
Livestock Market Reports (November 4, 2015)
Rain can be blessing, curse for farmers (November 4, 2015)
Ranch Rodeo fun in Nixon (November 4, 2015)
Ranching event set for Nov. 11 in Panna Maria (November 4, 2015)
Tips for spraying broccoli, cabbage (November 4, 2015)
Wet winter, spring is good news for hunters (November 4, 2015)
November 2015 Gardening Calendar (November 1, 2015)